Part 23 (1/2)
COMMON SIMPLE DYES.
433. _To Dye Black._
Allow a pound of logwood to each pound of goods that are to be dyed.
Soak it over night in soft water, then boil it an hour, and strain the water in which it is boiled. For each pound of logwood, dissolve an ounce of blue vitriol in lukewarm water sufficient to wet the goods. Dip the goods in--when saturated with it, turn the whole into the logwood dye. If the goods are cotton, set the vessel on the fire, and let the goods boil ten or fifteen minutes, stirring them constantly to prevent their spotting. Silk and woollen goods should not be boiled in the dye-stuff, but it should be kept at a scalding heat for twenty minutes.
Drain the goods without wringing, and hang them in a dry, shady place, where they will have the air. When dry, set the color by, put them into scalding hot water, that has salt in it, in the proportion of a tea-cup full to three gallons of the water. Let the goods remain in it till cold; then hang them where they will dry; (they should not be wrung.) Boiling hot suds is the best thing to set the color of black silk--let it remain in it till cold. Soaking black-dyed goods in sour milk, is also good to set the color.
434. _Green and Blue Dye, for Silks and Woollens._
For green dye, take a pound of oil of vitriol, and turn it upon half an ounce of Spanish indigo, that has been reduced to a fine powder. Stir them well together, then add a lump of pearl ash, of the size of a pea--as soon as the fermentation ceases, bottle it--the dye will be fit for use the next day. Chemic blue is made in the same manner, only using half the quant.i.ty of vitriol. For woollen goods, the East indigo will answer as well as the Spanish, and comes much lower. This dye will not answer for cotton goods, as the vitriol rots the threads. Wash the articles that are to be dyed till perfectly clean, and free from color.
If you cannot extract the color by rubbing it in hot suds, boil it out--rinse it in soft water, till entirely free from soap, as the soap will ruin the dye. To dye a pale color, put to each quart of soft warm water that is to be used for the dye, ten drops of the above composition--if you wish a deep color, more will be necessary. Put in the articles without crowding, and let them remain in it till of a good color--the dye-stuff should be kept warm--take the articles out without wringing, drain as much of the dye out of them as possible, then hang them to dry in a shady, airy place. They should be dyed when the weather is dry--if not dried quick, they will not look nice. When perfectly dry, wash them in lukewarm suds, to keep the vitriol from injuring the texture of the cloth. If you wish for a lively bright green, mix a little of the above composition with yellow dye.
435. _Yellow Dyes._
To dye a buff color, boil equal parts of arnotto and common potash, in soft clear water. When dissolved, take it from the fire; when cool, put in the goods, which should previously be washed free from spots, and color; set them on a moderate fire, where they will keep hot, till the goods are of the shade you wish. To dye salmon and orange color, tie arnotto in a bag, and soak it in warm soft soap suds, till it becomes soft, so that you can squeeze enough of it through the bag to make the suds a deep yellow--put in the articles, which should be clean, and free from color; boil them till of the shade you wish. There should be enough of the dye to cover the goods--stir them while boiling, to keep them from spotting. This dye will make a salmon or orange color, according to the strength of it, and the time the goods remain in. Drain them out of the dye, and dry them quick, in the shade--when dry, wash them in soft soap suds. Goods dyed in this manner should never be rinsed in clear water. Peach leaves, fustic, and saffron, all make a good straw or lemon color, according to the strength of the dye. They should be steeped in soft fair water, in an earthen or tin vessel, and then strained, and the dye set with alum, and a little gum arabic dissolved in the dye, if you wish to stiffen the article. When the dye-stuff is strained, steep the articles in it.
436. _Red Dyes._
Madder makes a good durable red, but not a brilliant color. To make a dye of it, allow for half a pound of it three ounces of alum, and one of cream of tartar, and six gallons of water. This proportion of ingredients will make sufficient dye for six or seven pounds of goods.
Heat half of the water scalding hot, in a clean bra.s.s kettle, then put in the alum and cream of tartar, and let it dissolve. When the water boils, stir the alum and tartar up in it, put in the goods, and let them boil a couple of hours; then rinse them in fair water--empty the kettle, and put in three gallons of water, and the madder; rub it fine in the water, then put in the goods, and set them where they will keep scalding hot for an hour, without boiling--stir them constantly. When they have been scalding an hour, increase the fire till they boil. Let them boil five minutes; then drain them out of the dye, and rinse them, without wringing, in fair water, and hang them in the shade, where they will dry. To dye a fine crimson, take for each pound of goods two and a half ounces of alum, an ounce and a half of white tartar--put them in a bra.s.s kettle, with sufficient fair water to cover your goods; set it where it will boil briskly for several minutes; then put in the goods, which should be washed clean, and rinsed in fair water. When the goods have boiled half an hour, take them out, without wringing, and hang it where it will cool all over alike, without drying; empty out the alum and tartar water, put fresh water in the kettle, and for each pound of goods to be dyed, put in an ounce of cochineal, powdered fine. Set the kettle on the fire, and let the water boil fifteen or twenty minutes; then put in sufficient cold water to make it lukewarm, put in the goods, and boil them an hour and a quarter--take them out without wringing, and dry them in a shady place. The blossoms of the Balm of Gilead, steeped with fair water in a vessel, then strained, will dye silk a pretty red color. The silk should be washed clean, and free from color, then rinsed in fair water, and boiled in the strained dye, with a small piece of alum. To dye a fine delicate pink, use a carmine saucer--the directions for dyeing come with the saucers. It is too expensive a dye for bulky goods, but for faded fancy shawls and ribbons, it is quite worth the while to use it, as it gives a beautiful shade of pink.
437. _Slate-Colored Dye._
To make a good dark slate color, boil sugar-loaf paper with vinegar, in an iron utensil--put in alum to set the color. Tea grounds, set with copperas, makes a good slate color. To produce a light slate color, boil white maple bark in clear water, with a little alum--the bark should be boiled in a bra.s.s utensil. The dye for slate color should be strained before the goods are put into it. They should be boiled in it, and then hung where they will drain and dry.
438. _Soap from Sc.r.a.ps._
Dissolve eighteen pounds of potash in three pailsful of water; then add to it twenty-five pounds of grease, and boil it over a slow fire for a couple of hours. Turn it into a barrel, and fill it up with water.
439. _Cold Soap._
Heat twenty-six pounds of strained grease. When melted, mix it with four pailsful of lye, made of twenty pounds of white potash. Let the whole stand in the sun, stirring it frequently. In the course of a week, fill the barrel with weak lye. This method of making soap is much easier than to make a lye of your ashes, while it is as cheap, if you sell your ashes to the soap-boiler.
440. _Hard Soap._
Dissolve twenty weight of white potash in three pailsful of water. Heat twenty pounds of strained grease, then mix it with the dissolved potash, and boil them together till the whole becomes a thick jelly, which is ascertained by taking a little of it out to get cold. Take it from the fire, stir in cold water till it grows thin, then put to each pailful of soap a pint of blown salt--stir it in well. The succeeding day, separate it from the lye, and heat it over a slow fire. Let it boil a quarter of an hour, then take it from the fire. If you wish to have it a yellow color, put in a little palm oil, and turn it out into wooden vessels.
When cold, separate it again from the lye, and cut, it in bars--let them remain in the sun several days to dry.